Parts Carousel System

This is a SOURCES SOUGHT NOTICE; not a pre-solicitation notice or solicitation for proposals/quotations. Pursuant to FAR Part 10 (Market Research), the purpose of this notice is to: (1) determine if sources capable of satisfying the agency's requirements exists, (2) determine if commercial items suitable to meet the agency's needs are available or could be modified to meet the agency's requirements, and (3) determine the commercial practices of company's engaged in providing the needed service or supply. Pursuant to FAR Part 6 and FAR Part 19, competition and set-aside decisions may be based on the results of this market research. This notice in no way obligates the Government to any further action. REQUIREMENT: This notice is issued by the U.S. Coast Guard, Surface Force Logistics Center, Baltimore, MD to identify sources capable of providing a parts carousel system, including installation, to replace the existing system located at USCG Yard, 2401 Hawkins Point Road, Baltimore, MD 21226. The carousels are enclosed by a wire partition and must meet the following minimum requirements: Carousel Area 1. Remove and dispose of existing carousels. The Government will provide scrap bins for material. 2. Fit within volume 243 inches wide, 672 inches long and 15 feet tall. 3. Area to be enclosed by a 10 foot high fence on two sides. 3 lockable doors will be provided at the front (pick side) of each carousel and 1 door will be provided at the back of the partition. 4. Suitable for existing concrete floor. 5. Clean and prepare area for installation of carousels. 6. Install new carousels and wire partitions. Carousels 1. Maximum power requirement is 100 amps, 240VAC, 1 Phase. 2. Maximum length 50 feet. Maximum width 65 inches. 3. Speed 60 Feet/Minute 4. 3 standalone 43 bin horizontal carousels. 5. Rated Live load of 1,500 lbs/bin. 6. Bin dimensions 96" tall, 24" wide, 16 " deep (24 cu ft). 7. 11 adjustable shelves/bin rated for 200 lbs each. 8. Plastic bins that may be used on shelves to hold small parts. 9. Metal components are galvanized or painted. 10. Minimal maintenance. 11. Photoelectric interlocks to prevent personnel injury at front and back of each carousel. 12. Foot pedal operation at front and rear of each carousel. 13. Emergency stops at the front and rear of each carousel. 14. Emergency stop reset button. 15. Keyboard controller that brings desired bin to distribution window. 16. NEMA 12 electrical component/distribution enclosures. The Government will allow competitive offers to be submitted for this requirement; however, all offers must provide a comparable parts carousel system that meets or exceeds the above minimum requirements. Concerns having the expertise and required capabilities to provide the equipment described in this notice are invited to submit complete information discussing the same within 14 calendar days from the day this notice is posted. Anticipated Period of Performance: It is anticipated that a firm, fixed priced one-time contract will be awarded for this acquisition. Delivery schedule is from award of contract to final installation of equipment. (Not to exceed one year in duration) Anticipated NAICS Code/Size Standard: The applicable NAICS Code is 423830, Remediation Services and the size standard is 100 employees. Submission of Information: Companies having capabilities necessary to meet or exceed the stated requirements are invited to provide information to contribute to this market survey/sources sought notice including commercial market information and company information. Companies may respond to this Sources Sought Notice via e-mail to walter.a.mackjr@uscg.mil no later than March 3, 2016 12:00 p.m., Eastern Time with the following information/documentation: 1. Name of Company, Address and DUNS Number. 2. Point of Contact and Phone Number. 3. Business Size applicable to the NAICS Code: 8(a) Small Business Concern; b. HubZone Small Business Concern; c. Service-Disabled Veteran Owned Small Business Concern (SDVOSBC); d. Veteran Owned Small Business Concern (VOSBC); e. ED Woman Owned Small Business Concern (EDWOSB); f. Woman Owned Small Business Concern (WOSBC); g. Small Business Concern; h. Large Business Concern 4. Documentation Verifying Small Business Certification: a. If claiming 8(a) status, provide a copy of your 8(a) Certificate from SBA. b. If claiming HuBZone status, provide a copy of your HuBZone Certificate from SBA. c. If claiming SDVOSBC status, provide documentation that shows the Service Disable Veteran (SDV) unconditionally owns 51 % of the business, controls the management and daily operations, and holds the highest officer position in the company. Documentation should also be provided to show that the SDV has a service-connected disability that has been determined by the Department of Defense or Department of Veteran Affairs. Finally, provide documentation that shows the business is small under the NAICS code 423830. d. If claiming VOSBC status, provide documentation that shows the Veteran unconditionally owns 51% of the business, controls the management and daily operation, make long-term decisions for the business, and holds the highest officer position in the company that works at the business fulltime during normal working hours. The documentation should also show the business is small under the NAICS code 423830. e. If claiming EDWOSB status, provide documentation that shows the company is at least 51% owned by one or more women who are "economically disadvantaged", and primarily managed by an economically disadvantaged woman that make long-term decisions for the business, hold the highest officer position in the business and work at the business full-time during normal working hours. The documentation should also show the business is small under the NAICS code 423830. A woman is presumed economically disadvantaged if she has a personal net worth of less than $750,000 (with some exclusions), her adjusted gross yearly income averaged over the three years preceding the certification less than $350,000, and the fair market value of all her assets is less than $6 million f. If claiming Woman Owned Small Business status, provide documentation that shows the company is at least 51% owned and controlled by one or more women, and primarily managed by one or more women that make long-term decisions for the business and hold the highest officer position in the business and work at the business full time during normal working hours. The women must be U.S. citizens. The documentation should also show the business is small under the NAICS code 423830. g. If claiming Small Business status, provide documentation to show the business is small under NAICS code 423830. 5. Statement of Proposal Submission: Statement on how your company will do the work and that your company WILL submit a proposal as a prime contractor if a solicitation is issued as a result of this Sources Sought Notice. 6. Past Performance Information: Evidence of experience in work similar in type and scope to include contract numbers, project titles, and dollar amounts, points of contact and telephone numbers. If two companies are planning to conduct business and submit an offer as a Joint Venture or similar type of teaming agreement, they are requested to provide past performance information on projects of similar scope that they have performed together as a Joint Venture, if available. Providing individual past performance documentation from each company on separate projects where the two did not work together may be considered less relevant. SAM: Interested parties should register in the System for Award Management (SAM) as prescribed in FAR Clause 52.232-33. SAM can be obtained by accessing the internet at www.sam.gov or by calling 1-866-606-8220. Disclaimer and Important Notes: This Sources Sought Notice is for market research purposes only and does not constitute a Request for Proposal/Quotation; and, it is not considered to be a commitment by the Government to award a contract nor will the Government pay for any information provided; no basis for claim against the Government shall arise as a result from a response to this Sources Sought Notice or Government use of any information provided. Failure to respond or submit information in sufficient detail may result in a company not being considered a likely offeror when making a decision on whether or how to set aside a solicitation for restricted competition. Regardless of the information obtained from this Sources Sought Notice, the Government reserves the right to consider any arrangement as deemed appropriated for this requirement. Respondents are advised that the Government is under no obligation to acknowledge receipt of the information received or provide feedback to respondents with respect to any information submitted. No proprietary, classified, confidential, or sensitive information should be included in your response to this Sources Sought Notice. The Government reserves the right to use any information provided by respondents for any purpose deemed necessary and legally appropriate, including using technical information provided by respondents in any resultant solicitation. At this time no solicitation exists; therefore, DO NOT Request a Copy of the Solicitation. After a review of the responses received, a pre-solicitation notice and solicitation may be published on Federal Business Opportunities (FedBizOpps) website. It is the potential offeror's responsibility to monitor FedBizOpps for release of any future solicitation that may result from this Sources Sought Notice. However, responses to this Sources Sought Notice will not be considered adequate responses to any resultant solicitation.