J041--Cooling Tower Maintenance and Repair Service

Department of Veterans Affairs Network Contracting Office (NCO) 16 Request For Information (RFI) DISCLAIMER: THIS IS A SOURCES SOUGHT NOTICE ONLY. THIS SYNOPSIS IS NOT A REQUEST FOR QUOTE, PROPOSAL, OR BID. This notice is not a solicitation as defined by FAR 2.101, therefore it shall not be construed as a commitment by the Government to enter into a contract, nor does it restrict the Government to an acquisition approach. All information contained in this Request for Information (RFI) is preliminary as well as subject to amendment and is in no way binding on the Government. Information submitted in response to this notice is voluntary; the Government will not pay for information requested nor will it compensate any respondent for any cost incurred in developing information provided to the Government. The Government is requesting that restrictive or proprietary markings not be used in response to this notice. If a solicitation is released, it will be synopsized in the Federal Contract Opportunities website or GSA. It is the responsibility of the interested parties to monitor these sites for additional information pertaining to this RFI. 1. Title: Cooling Tower Maintenance and Repair Service 2. Purpose: The purpose of this RFI is to identify potential sources which will aid in defining the procurement strategy (e.g., set-aside, sole source, unrestricted) for a solicitation the VA intends on issuing shortly for the following: Scope of Work Cooling Tower Maintenance and Repair Service G.V. Sonny Montgomery VA Medical Center (GVSMVAMC) Facility Management Service 1500 E Woodrow Wilson Drive Jackson, MS 39216 1. OBJECTIVE: The G.V. Sonny Montgomery VA Medical Center located in Jackson, MS requires the following services for the facility: Cooling Tower Maintenance and Repair Service as required by (and in accordance with) Joint Commission Standards, Occupational Safety and Health Administration (OSHA) Standards, and other regulations/policies that are applicable. 2. GENERAL: This is a non-personnel services requirement. The contractor shall provide all management, supervision, labor, transportation, tools, materials, parts, and other items necessary to perform work, execute services, and to successfully complete all deliverables as contained within this Scope of Work. The Government shall not exercise any supervision and/or control over contractor personnel (which includes contractor service providers, contractor representatives, and subcontractors employed with and/or being utilized by the prime contractor) during all active performance periods of the contract. All contractor personnel shall be accountable solely to the Contractor, who in turn is responsible to the Government. 3. BACKGROUND: The Department of Veterans Affairs, G.V. Sonny Montgomery VA Medical Center, has a requirement to perform annual preventive maintenance, cleaning, general repairs, and emergency repairs to the cooling towers that provides cooling water to the facility chiller plant and other essential equipment. 4. SCOPE OF SERVICES: Services needed under this effort (to include required Deliverables) will be executed for the cooling towers annotated in the table below: TABLE A COOLING TOWERS ITEM MANUFACTURER MODEL DESCRIPTION CAPACITY LOCATION Tower Cell #1 Baltimore Air Coil (BAC) 3872A/V-4 304 Stainless Steel Updraft Cooling Tower 2,400 gpm per cell Exterior Central Utility Plant Tower Cell #2 Baltimore Air Coil (BAC) 3872A/V-4 304 Stainless Steel Updraft Cooling Tower 2,400 gpm per cell Exterior Central Utility Plant Tower Cell #3 Baltimore Air Coil (BAC) 3872A/V-4 304 Stainless Steel Updraft Cooling Tower 2,400 gpm per cell Exterior Central Utility Plant Tower Cell #4 Baltimore Air Coil (BAC) 3872A/V-4 304 Stainless Steel Updraft Cooling Tower 2,400 gpm per cell Exterior Central Utility Plant Tower Cell #5 Baltimore Air Coil (BAC) FXV-0806B 304 Stainless Steel Updraft Cooling Tower 2,400 gpm per cell Exterior Central Utility Plant Cooling Tower Preventative Maintenance/Cleaning (Annually) Perform preventative maintenance/cleaning to cooling tower cells (5). Perform preventative maintenance to cooling tower pumps/motors (5). Perform preventative maintenance to cooling tower fans/motors (5). Conduct a visual inspection of the cooling tower s exterior. Look for any signs of physical damage, corrosion, or leaks. Check the structural integrity, fan blades, louvers, and access doors. Perform a detailed inspection of the entire cooling tower system, including mechanical and electrical components. Inspect drift eliminators and fill material for any blockages, obstructions, or signs of wear and tear. Repair or replace any damaged fill material. Clear any debris or scaling from the drift eliminators and ensure that the fill material is intact and evenly distributing water throughout each cell. Inspect fan system. Inspect the blades of fan for any damage or imbalance. Verify that the fan motor, coupling, and gearbox are in good condition and properly aligned. Lubricate bearings and change gearbox oil as recommended by the manufacturer. Check fan belts and adjust belt tension and lubricate motor base adjusting screw. Repair or replace any damaged components. Ensure the water distribution system has even water flows over the fill material. Check for clogged or malfunctioning spray nozzles. Adjust or replace any faulty nozzles to maintain consistent water distribution and prevent dry spots which cause inefficient cooling. Inspect and clean water basins and sumps. Inspect and clean exterior. Cold water basin and sump are susceptible to debris buildup, sediment, and microbiological growth. Drain and clean the basin thoroughly. Remove any accumulated dirt, leaves, or other foreign objects. Scrub cells in their entirety and power wash. Use a suitable biocide or cleaning agent to eliminate bacteria, algae, and fungi that can lead to fouling and reduced performance. Conduct a thorough cleaning and inspection of water piping and associated equipment. Examine the water piping system for leaks, corrosion, or blockages. Remove any scale or deposits that may have accumulated. Check valves, fittings, and couplings for proper operation and tightness. Check for damaged piping insulation and replace as necessary. Check operation of heat strips and replace as necessary. Repair or replace any damaged components as necessary. Contractor shall provide a detailed report of all deficiencies found during annual inspection of cooling tower system. Report will be digital in nature and list all findings and necessary corrections. Contractor has 14 days to submit report to COR. Contractor will be responsible for repairs found during annual inspection up to $10,000.00 per year of contract. Contractor will provide line-item detail report of all repairs and costs associated. Any additional parts, materials, or services over specified amount shall be addressed thru a unilateral modification of contract. Any unused funds from repair allocation shall be de-obligated at end of year of contract. Cooling Tower Emergency Repair Service Contractor will provide four (4) emergency service calls during each year of contract (one call per quarter). Contractor is responsible for all labor and travel costs and up to $3500.00 in parts/materials. Contractor will provide line-item detail service report of any service call and costs associated. Any additional parts, materials, or services over specified amount shall be addressed thru a unilateral modification of contract. Any unused funds from service call allocation shall be de-obligated at end of year of contract. Contractor shall be on site within 4 hours of notification. 5. PLACE AND PERIOD OF PERFORMANCE: Work will be performed, services will be executed, and deliverables will be completed at G.V. Sonny Montgomery VA Medical Center, 1500 E Woodrow Wilson Drive, Jackson, MS 39216. This project, as encompassed by the final contract when executed, will consist of a (1) base year and (4) 12-month option years of service for the facility. Contract performance will end when the contract is successfully completed. 6. WORK HOURS AND SCHEDULE: All work, execution of services, and completion of deliverables must be accomplished during normal business hours, 8:00 a.m. through 4:30 p.m. Monday through Friday and during the Months November to January but not when the ambient air temperature is below 32 degrees F, Federal Holidays excluded. Prior to work being performed proper coordination shall be initiated between the contractor and the government to ensure that services/work can be executed when scheduled. Any work, services, and/or other tasks performed during other than normal business hours must be approved in advance by the Contracting Officer Representative (COR), Contracting Officer, and/or other authorized facility designee/representative before such work begins. The Federal Holidays that are currently being observed by the facility are listed in the table below. New Year s Day January 1 Martin Luther King s Birthday Third Monday in January President s Day Third Monday in February Memorial Day Last Monday in May Juneteenth Independence Day June 19th Independence Day July 4 Labor Day First Monday in September Columbus Day Second Monday in October Veterans Day November 11 Thanksgiving Day Fourth Thursday in November Christmas Day December 25 Other Federal Holidays (that could occur) Any other day specifically declared to be a national holiday (per Federal Statute, Executive Order, or by the President s Proclamation). An alternative schedule (different from the schedule described above) may be utilized if there is mutual agreement between the government and the contractor regarding this alternative schedule if implemented. 7. PERSONNEL PERFORMING WORK/SERVICES - REQUIRED CORE COMPETENCIES : Personnel performing work, executing services, and completing deliverables during the active performance periods of the contract shall possess the knowledge, skills, and abilities required to successfully accomplish the following: Cooling Tower Maintenance and Repair Service. No unqualified individual shall be allowed to perform work, execute services, and to complete deliverables at any time under the contract while active. 8. KEY PERSONNEL During the active performance periods of the contract a Key Personnel Person shall be designated by the contractor (to be contacted by the government when needed) regarding performance of work, execution of services, and completion of Deliverables as contained within this Scope of Work and covered by the final contract. This Key Personnel person must have sufficient knowledge to be able to respond to technical questions by the government. 9. DELIVERABLES: Required Deliverables DELIVERABLE #1: ROUTINE REPORTING, DOCUMENTATION, AND SERVICE LOG Documentation shall be provided following execution of services, performance of work, and completion of deliverables during the active performance periods of the contract. A service log describing the efforts completed under the final contract shall be prepared, maintained, and provided to the government by the contractor on a reoccurring basis so that the government can have proper oversight of project completion as defined by the final contract. Documentation shall include detailed descriptions of the progress made, efforts undertaken, and work/services/deliverables that were successfully completed by the contractor (while at the facility). Reporting requirements under this deliverable also includes (or otherwise encompasses) the reporting standards as previously stated in Section 4 of this Scope of Work. DELIVERABLE #2: CHECK IN AND CHECK OUT PROCEDURES Before beginning any work at any time during the active performance periods of the contract personnel performing services must physically check in with the COR to obtain approval and confirmation of the expected work to be performed and services to be executed. Check out procedures will be the same once work has been completed and services have been executed. Check in and check out procedures shall include the following: 1). Written documentation of the contractor s arrival and departure while on site and 2). Written documentation showing the expected work to be performed, approval of such work before such work begins, and confirmation/completion status of the planned work that was scheduled to be performed. Facility personnel and the contractor may modify such procedures if there is mutual agreement among both parties regarding changes to these procedures if implemented. 10. RECORDS MANAGEMENT Contractor shall comply with all applicable records management laws and regulations, as well as National Archives and Records Administration (NARA) records policies, including but not limited to the Federal Records Act (44 U.S.C. chs. 21, 29, 31, 33), NARA regulations at 36 CFR Chapter XII Subchapter B, and those policies associated with the safeguarding of records covered by the Privacy Act of 1974 (5 U.S.C. 552a). These policies include the preservation of all records, regardless of form or characteristics, mode of transmission, or state of completion. In accordance with 36 CFR 1222.32, all data created for Government use and delivered to, or falling under the legal control of, the Government are Federal records subject to the provisions of 44 U.S.C. chapters 21, 29, 31, and 33, the Freedom of Information Act (FOIA) (5 U.S.C. 552), as amended, and the Privacy Act of 1974 (5 U.S.C. 552a), as amended and must be managed and scheduled for disposition only as permitted by statute or regulation. In accordance with 36 CFR 1222.32, Contractor shall maintain all records created for Government use or created while performing the contract and/or delivered to, or under the legal control of the Government and must be managed in accordance with Federal law. Electronic records and associated metadata must be accompanied by sufficient technical documentation to permit understanding and use of the records and data. G.V. Sonny Montgomery VAMC (GVSMVAMC) and its contractors are responsible for preventing the alienation or unauthorized destruction of records, including all forms of mutilation. Records may not be removed from the legal custody of [Agency] or destroyed except for in accordance with the provisions of the agency records schedules and with the written concurrence of the Head of the Contracting Activity. Willful and unlawful destruction, damage or alienation of Federal records is subject to the fines and penalties imposed by 18 U.S.C. 2701. In the event of any unlawful or accidental removal, defacing, alteration, or destruction of records, Contractor must report to [Agency]. The agency must report promptly to NARA in accordance with 36 CFR 1230. The Contractor shall immediately notify the appropriate Contracting Officer upon discovery of any inadvertent or unauthorized disclosures of information, data, documentary materials, records or equipment. Disclosure of non-public information is limited to authorized personnel with a need-to-know as described in the [contract vehicle]. The Contractor shall ensure that the appropriate personnel, administrative, technical, and physical safeguards are established to ensure the security and confidentiality of this information, data, documentary material, records and/or equipment is properly protected. The Contractor shall not remove material from Government facilities or systems, or facilities or systems operated or maintained on the Government s behalf, without the express written permission of the Head of the Contracting Activity. Contractor personnel shall sign VA Form 10-0708 Employee Clearance from Indebtedness before resigning or termination from Contractor working for GVSMVAMC and Facility Records Officer must sign form. A copy of completed signed VA Form 10-0708 (Contractor personnel and Facility Records Officer signatures) shall be place in each competency folder. When information, data, documentary material, records and/or equipment is no longer required, it shall be returned to [Agency] control or the Contractor must hold it until otherwise directed. Items returned to the Government shall be hand carried, mailed, emailed, or securely electronically transmitted to the Contracting Officer or address prescribed in the [contract vehicle]. Destruction of records is EXPRESSLY PROHIBITED unless in accordance with Paragraph (4). The Contractor is required to obtain the Contracting Officer's approval prior to engaging in any contractual relationship (sub-contractor) in support of this contract requiring the disclosure of information, documentary material and/or records generated under, or relating to, contracts. The Contractor (and any sub-contractor) is required to abide by Government and [Agency] guidance for protecting sensitive, proprietary information, classified, and controlled unclassified information. The Contractor shall only use Government IT equipment for purposes specifically tied to or authorized by the contract and in accordance with GVSMVAMC policy. The Contractor shall not create or maintain any records containing any non-public GVSMVAMC information that are not specifically tied to or authorized by the contract. The Contractor shall not retain, use, sell, or disseminate copies of any deliverable that contains information covered by the Privacy Act of 1974 or that which is generally protected from public disclosure by an exemption to the Freedom of Information Act. The GVSMVAMC owns the rights to all data and records produced as part of this contract. All deliverables under the contract are the property of the U.S. Government for which GVSMVAC shall have unlimited rights to use, dispose of, or disclose such data contained therein as it determines to be in the public interest. Any Contractor rights in the data or deliverables must be identified as required by FAR 52.227-11 through FAR 52.227-20. Training. All Contractor employees assigned to this contract who create, work with, or otherwise handle records are required to take [Agency]-provided records management training. The Contractor is responsible for confirming training has been completed according to agency policies, including initial training and any annual or refresher training. TMS (Talent Management System) course VA 4192704: Records Management for Everyone [Note: To the extent an agency requires contractors to complete records management training, the agency must provide the training to the contractor.] Flow-down of requirements to subcontractors: The Contractor shall incorporate the substance of this clause, its terms and requirements including this paragraph, in all subcontracts under this [contract vehicle], and require written subcontractor acknowledgment of same. Violation by a subcontractor of any provision set forth in this clause will be attributed to the Contractor. 11. OTHER REQUIREMENTS: 11.1 Identification and Badges: Any individual performing work under this contract shall wear a badge or other identification while on site that is clearly displayed at all times. While on site, any person performing work directly or indirectly must be in a position to specify their authorized purpose for their presence at the facility in the event that such information is requested by VA facility personnel. 11.2 Parking: It is the responsibility of the contractor to park in the appropriate designated parking areas, to avoid ticketing or towing. Information on parking is available from the facility if requested by the contractor. 11.3 Contract Administration: The Contracting Officer is the only person authorized to approve changes or modify any of the requirements under this contract. The Contractor shall communicate with the Contracting Officer on all matters pertaining to contract administration. Only the Contracting Officer is authorized to make commitments or issue changes that will affect price, quantity, or quality of performance of this contract. In the event the Contractor makes any such change at the direction of any person other than the Contracting Officer, this change shall be considered to have been made without authority and no adjustment will be made in the contract price to cover any increase in costs incurred as a result thereof. All changes to the contract will be issued via an amendment and/or modifications in writing from the Contracting Officer to the Contractor. 11.4 Invoicing and Payment: Contractor is authorized prompt payment IAW applicable regulation following the successful performance of work, execution of services, and completion of required deliverables. Contractor invoices shall be submitted IAW VAAR Clause 852.232-72 Electronic Submission of Payment Requests. Invoices submitted for payment must be detailed to the extent necessary to reflect the work done and the services performed during the time periods when completed so an accurate assessment can be made by the facility for certification of these invoices for payment. Advance payments are not authorized, and contractor is not authorized payment for future work not performed and/or for work that has not been successfully completed. The anticipated Small Business Administration (SBA) size standard for the North American Industry Classification System (NAICS) code _811310__________ is _$12.5M___________ (employees or dollars). 3. Responses Requested: The following questions must be answered in response to this RFI. Answers that are not provided shall be considered non-responsive to the RFI: a. Where are the requested items/equipment manufactured? Vendor must attach documentation of this information to be viewed by the government to be considered as part of the Market Research and responsiveness to this Sources Sought notice b. Are the requested items/equipment manufactured by a Small or Large business? Is the potential vendor in compliance with the Non-Manufacturer Rule (NMR)? Vendor must attach documentation of this to be viewed by the government to be considered as part of the Market Research and responsiveness to this Sources Sought notice c. Is the Vendor an authorized distributor with access to Original Equipment Manufacturer (OEM) parts which may be required in performance of this requirement? The VA does not accept grey market items and therefore the Vendor must attach evidence of this access (Authorized Distributor letter) to be viewed by the government to be considered as part of the Market Research and responsiveness to this Sources Sought notice. d. Name of potential Contractor that possess the capability to fulfill this requirement. Contractors shall also provide the following: Point(s) of contact name: _______________________________________________ Address: ___________________________________________________ Telephone number: ___________________________________________ Email address: _______________________________________________ Company's business size: ________________________________________________ Data Universal Numbering System (DUNS) #: _______________________________ e. Is your company considered a small business concern, SB, SDVOSB, VOSB, HUBZone, or 8A concern, with the requisite __________________ NAICS code? Please provide proof of qualifications. f. Is your company available under any Government Wide Agency Contract (GWAC), General Services Administration (GSA) Schedule, Indefinite Delivery Indefinite Quantity (IDIQ), and/or Blanket Purchase Agreement (BPA)? If so, please identify the contract number for the Government to review as part of this Market Research. 4. Opportunity/Market Pricing: The VA VISN 16 is seeking information from potential vendors on their ability to provide the required items/equipment. THIS IS A SOURCES SOUGHT REQUEST FOR INFORMATION (RFI) ONLY. Small Business Concerns are encouraged to provide responses to this RFI in order to assist the MEDVAMC in determining potential levels of competition and general market pricing available in the industry. Therefore, vendors are requested to submit estimated market research pricing along with their responses to the above. The estimated pricing will be considered when determining the procurement strategy for the forthcoming solicitation. 5. Instructions and Response Guidelines: Questions regarding this RFI shall be submitted no later than 14:00 (CST), November 11, 2023 via email to contact@example.gov RFI responses are due by 14:00pm (CST), Wednesday, November 13, 2023; size is limited to 8.5 x 11 inches, 12-point font, with 1-inch margins in Microsoft Word format via email to contact@example.gov The subject line shall read: Cooling Tower Maintenance and Repair Service. NO SOLICITATION EXISTS AT THIS TIME. There is no page limitation on subparagraphs 3(a) - 3(f). Please provide the information you deem relevant in order to respond to the specific inquiries of the RFI. Information provided will be used solely by MEDVAMC as Market Research and will not be released outside of the MEDVAMC Purchasing and Contract Team. 7. Contact Information: Reggie Clark contact@example.gov Your response to this notice is greatly appreciated!